Airbag Falsing Sensor.JPG
8128 hits | 56.45 KB | Posted: 11/25/05
Bronco airbag safing sensor at base of R B-pillar '94-96 ONLY.

See also:
. [url=https://www.supermotors....
(Posted in: General Purpose Pics)

CruiseVacuum92Dash.jpg
8127 hits | 61.63 KB | Posted: 11/9/05
Vacuum Cruise Underdash

See also:
. [url=http://www.supermotors.net/vehicles/registry/media/894...
(Posted in: Diagrams)

EUL-IMS.jpg
8126 hits | 76.08 KB | Posted: 4/10/06
EMW/IMS(EUL) COMBO module, found on the back of the instrument cluster in '87-89 V8s.

Emissions Maintenance Warning / Inferred Mileage Sensor
[url=http://www.supermotors.net/registry/media/544459][img]http://www.supermotors.net/getfile/544459/thumbn...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

T-caseShifter92.jpg
8121 hits | 35.51 KB | Posted: 4/18/07
TSB 93-2-11 Buzz or Rattle through the 4X4 Manual Shift Lever
Publication Date: JANUARY 18, 1993

Applies to: LIGHT TRUCK: 1992 BRONCO, F-150-350 SERIES

ISSUE: A "buzz" or "rattle" may be heard through the 4X4 transfer case shif...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

03DashLoose.JPG
8102 hits | 90.85 KB | Posted: 11/11/05
There's no need to disconnect the wiring or vacuum lines on the driver's side since this provides enough access to work. With the hoses & 3 nuts already removed, the box can now be pulled from the firewall. The top stud has a push-nut holding it to...
(Posted in: Heater Core)

92F2G.JPG
8101 hits | 68.25 KB | Posted: 12/9/11
2G Alternator on a '92 F150 5.0L
'93-up have a 3G alternator. All 2Gs are fire hazards, despite the TSB below. They should all be upgraded to 3G, and it's nearly a PnP swap.

[url=https://www.supermotors.net/registry/media/566009][img]https://www.s...
(Posted in: General Purpose Pics)

Filler.JPG
8098 hits | 84.1 KB | Posted: 7/12/03
Filler Neck
Loosen the hose clamp at the tank & pull the outer filler neck off the tank. There is another hard plastic hose inside ('87-96), which also must be guided out of the tank.

The extra bolts in the body are for the dealer-option 3rd-row ju...
(Posted in: '90-96 Fuel Pump System)

Disc8.8Axle04E150.JPG
8096 hits | 77.46 KB | Posted: 5/16/07
Disc 8.8" from '04-06 E150 with 5x5.5" lug spacing requires 16" rims
IF THE IMAGE IS TOO SMALL, click it.

1 Rear axle identification tag (part of 4001)
2 Differential housing cover bolt 4346
3 Differential housing cover 4033
4 D...
(Posted in: Brakes & Hubs)

TPS chart 1.jpg
8085 hits | 88.88 KB | Posted: 1/29/05
TPS Application Chart CARS

See this diagram for TRUCKS:

See this diagram for testing:
[url=http://www.superm...
(Posted in: Diagrams)

AutelAL309.jpg
8083 hits | 61.99 KB | Posted: 6/18/09
Autel.us AutoLink AL309



For under $30, this reads & clears OBD-II codes ('96-up), and displays PIDs (li...
(Posted in: General Purpose Pics)

Module 1.JPG
8078 hits | 110.09 KB | Posted: 7/12/03
Reservoir Removal
Remove the level sender upper mounting screw, press & hold the lock clip down, then lift the tube assembly from the reservoir.

The reservoir (which contains the pump, the return valve, & the pickup siphon) is interchangeable betwee...
(Posted in: '90-96 Fuel Pump System)

Key Card.JPG
8075 hits | 36.41 KB | Posted: 9/12/05
TSB 92-08-04 Cutting Plastic Keys
Publication Date: APRIL 8, 1992

FORD: 1991-92 CROWN VICTORIA, ESCORT, MUSTANG, PROBE, TAURUS, TEMPO, THUNDERBIRD
LINCOLN-MERCURY: 1991-92 CAPRI, CONTINENTAL, COUGAR, GRAND MARQUIS, MARK VII, SABLE, TOPAZ, TOWN CAR...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

Alt94Tbird.JPG
8072 hits | 103.74 KB | Posted: 9/20/07
This is going to replace the crappy '88 2G alternator. The 130A 3G alternators are easily identifiable by the 2 large holes between each pair of ribs on the front case. Those with 4 holes are 95A.

[url=https://www.supermotors.net/registry/media/10...
(Posted in: Phase 3)

ExhaustEFI.JPG
8057 hits | 61.05 KB | Posted: 7/19/12
1/2-ton EFI Exhaust
IF THE IMAGE IS TOO SMALL, click it.

Before madly ripping out all the emissions systems on your vehicle, read this article.

'95-96 MAF has 2 up...
(Posted in: Diagrams)

EVPgraph.jpg
8056 hits | 23.89 KB | Posted: 6/30/09
EVP Output Graph

Voltage is measured from the Br/LG wire (EVP) to Gy/R (SigRet) with the key in RUN and the sensor connected normally. Check Br/Wh (VRef) to Gy/R for 5VDC. Use a handheld vacuum pump (e.g. MityVac) to operate the EGR valve.

[url=h...
(Posted in: Diagrams)

Picture 013.mpg
8054 hits | 1.41 MB | Posted: 9/29/03
(Posted in: videos)

DetroitLockerD80.JPG
8017 hits | 79.94 KB | Posted: 3/16/07
Detroit locker offered as OE in some Ford Dana 80 rear axles.

1 Case Assy.
2 Thrust Washer
3 Side Gear
4 Preload Dampener Kit
5 Spring Retainer
6 Spring
7 Clutch Assy.
8 Central Driver Assy.
9 Case Bolt (8 Req'd.)

The locking differen...
(Posted in: Diagrams)

Timing Pointer.JPG
8005 hits | 102.12 KB | Posted: 7/11/03
Timing Pointer & Misfire Sensor used only on '96 OBD-II smallblock engines. The lower L pulley is a factory idler where the unneeded air pump used to go. The '96 cats are Oxygen-storing, so they don't need 2ndry air.

[url=http://www.supermotors.ne...
(Posted in: Base Album)

Tailgate TrimPanel.jpg
8004 hits | 46.91 KB | Posted: 10/14/05
Trim Panel '87-96

F-series A clips are plastic & fragile. Replacements have recently become available:
Trim Panel Mounting Clips (E7TB9942502,E7TB9942596,E9TB994250,E9TB9942596)

http://shop.autocraft...
(Posted in: Tailgate Tech)

ChokeHeatTube.JPG
8002 hits | 61.87 KB | Posted: 11/9/11
Choke Heater Tube

The choke housing on the carburetor has a restricted journal to vacuum, which draws air in from the fiber-wrapped heat tube. The tube comes from a fitting on the exhaust manifold connected to a pass-through tube that collects heat...
(Posted in: Diagrams)

B6.JPG
7998 hits | 94.17 KB | Posted: 7/13/03
Install Caliper Slide Clips (Ford F2TZ2C150A; MC BRCK5030) with locking tabs facing the steering knuckle. They should also have a light coat of brake grease where they touch the caliper, and those surfaces should be otherwise clean.

[url=https://ww...
(Posted in: Brakes & Hubs)

DashPad92-96.jpg
7996 hits | 40.44 KB | Posted: 10/16/05
'92-96 Dash Pad

. [url=https://www.supermotors.net/registry/media/1127378][img]https://www.supermotors.net/getf...
(Posted in: Diagrams)

Wire Unclipped.JPG
7993 hits | 36.81 KB | Posted: 11/29/04
To get enough slack in the wire to pull the motor out & work on it, remove the clip from the bottom of the tailgate. Remember to reinstall it later, or the wire could become entangled in the glass or regulator.

That hook on the L side is the bott...
(Posted in: Tailgate Tech)

C418.JPG
7990 hits | 66.26 KB | Posted: 9/12/07
This is all the wiring for the tailgate, except the ground for the defrost grid. This connector is located inboard of the L frame rail between the rear bumper & the gas tank rear crossmember.

[url=https://www.supermotors.net/registry/media/1172069]...
(Posted in: Tailgate Tech)

P6250041.JPG
7976 hits | 82.16 KB | Posted: 6/26/05
(Posted in: Factory Tech Valve Body install)

Oil Flow.jpg
7974 hits | 61.46 KB | Posted: 1/2/05
Oil flow for 4.6L modular engine
(Posted in: Diagrams)

T-case95EVTM.jpg
7941 hits | 36.09 KB | Posted: 1/22/05
ESOF T-Case 95 Bronco
IF THE IMAGE IS TOO SMALL, click it.

. [url=http://www.supermotors.net/regist...
(Posted in: Diagrams)

J 1.JPG
7938 hits | 94.38 KB | Posted: 7/12/03
Lock Ring
Cleaning also makes it much easier to turn the ring.
(Posted in: '90-96 Fuel Pump System)

CB_Mount.JPG
7922 hits | 31.61 KB | Posted: 6/30/03
My overhead console is made of 2 pieces of sheet metal. The first one (visible around the scanner) is screwed to the roof. The second is covered in 1/8" foam & cheap duck canvas from Wal-Mart, and it hangs on the upper w/s trim & 2 screw heads...
(Posted in: 83 Bronco, Mk.1 & Mk.2)

BattTermLF.JPG
7917 hits | 63.31 KB | Posted: 4/28/09
Late-Model OE-style Battery Terminals ~$10ea @ NAPA

The "lead-free" description is misleading. The other solder-on terminals are also lead-free; they're brass or copper with a tin or silver-solder coating.

But this style may be a better ...
(Posted in: Solder-On Battery Terminals)

Axle ID 91-93.jpg
7907 hits | 69.08 KB | Posted: 7/26/03
Axle '91-93 Applications

. [url=http://www.supermotors.net/registry/media/170512][img]http://www.supermotors.net...
(Posted in: Diagrams)

FuelLines92.JPG
7902 hits | 65.1 KB | Posted: 5/1/12
'92-96 Fuel Lines (gas)


(Posted in: '90-96 Fuel Pump System)

Axle ID 87-90.jpg
7897 hits | 59.09 KB | Posted: 7/26/03
Axle '87-90 Applications

. [url=http://www.supermotors.net/registry/media/170512][img]http://www.supermotors.net...
(Posted in: Diagrams)

97_F350.jpg
7896 hits | 28.85 KB | Posted: 6/30/03
(Posted in: 97 F350)

Swingaway Brace.JPG
7895 hits | 71.44 KB | Posted: 11/29/04
Before removing the regluator, remove the tire carrier's strike brace (if equipped).


(Posted in: Tailgate Tech)

lifted explorer.jpg
7891 hits | 35.02 KB | Posted: 3/15/06
maybe idea to put on my chasis
(Posted in: Misc.)

RABS Troubleshooting 92.jpg
7887 hits | 67.8 KB | Posted: 1/13/06
RABS & RABS-II Troubleshooting
IF THE IMAGE IS TOO SMALL, click it.

Flashout Codes

Whenever the yellow REAR ABS light comes on during normal operation, a flashout code may be obtained to aid in problem diagnosis. If the vehicle is shut off before t...
(Posted in: Brakes & Hubs)

TirePressures92.JPG
7880 hits | 115.33 KB | Posted: 10/24/10
Tire Sizes & Pressures 1/2-ton

See also:
. [url=http://www.supermotors.net/registry/media/491879_1][...
(Posted in: Diagrams)

Rack Ready.JPG
7872 hits | 63.26 KB | Posted: 7/13/03
I cut the front of the tracks down by 1 screw hole and installed 2 rear crossbars because they can both be (re)moved without tools. The original front bar is screwed in place, so I deleted it. I also added more tie-downs.

Outside dimensions (after...
(Posted in: Camper Shell & Sliding Side Windows)

Fuse Cover 83.jpg
7853 hits | 73.6 KB | Posted: 12/20/04
Fuse Cover 1983 Bronco

See also:
http://www.revbase.com/BBBMotor/Wd
. [url=http://www.supermotors.net/registry...
(Posted in: Diagrams)

CruiseRecall1.jpg
7843 hits | 18.51 KB | Posted: 7/25/05
Combine http://www.supermotors.net/getfile/505128/fullsize/fsa05s28speedcontroldeacsw.jpg
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

FuelLines91.JPG
7841 hits | 62.19 KB | Posted: 5/1/12
'86-91 Fuel Lines

Garter Spring Safety Clips w/tethers
9mm E7AZ9A317A (E7AZ9A317AA)
12.5mm E7AZ9A317B (E7AZ9A317BA)

[url=https://www.supermotors.net/registry/media/950180_1][img]https://www.supermotors.net/getfile/950180/thumbnail/fuelflow.jpg[/img...
(Posted in: '90-96 Fuel Pump System)

LeslieT3.jpg
7837 hits | 37.39 KB | Posted: 8/2/05
Leslie Wolfe Midday Chick Wet T-Shirt Contest Winner
(Posted in: WEGR)

FuelPumpEarlyEFI.JPG
7831 hits | 73.5 KB | Posted: 10/12/10
Hi-Pressure Fuel Pump, Filter, & Dual-Function Reservoir F1UZ-9B263-B for '84-89 EFI
IF THE IMAGE IS TOO SMALL, click it.

[url=http://www.supermotors.net/registry/media/507187][img]http://www.supermoto...
(Posted in: '84-89 Fuel Reservoirs)

bronco-4-2006_029.jpg
7830 hits | 61.57 KB | Posted: 4/25/06
tighten nuts on both sides until they stop (100-120 ft.lbs.)
(Posted in: axle pivot bushing tool)